Scotsman DCE33 Manual de Serviço

INTRODUCTIONThe Scotsman DCE33 is a restaurant type icemachine designed for home use. It produces thesame high quality ice as large Scotsmancommercial

TO INSTALL: Add On KitsDoor Kit: The door may be modified to accept adecorator door panel.Customizing Door Panel:A custom door panel may be installed

AFTER INSTALLATIONReversing Door Swing:The hinged side of the door may be reversed tothe other side if desired:The DCE33 was shipped with the door hin

AFTER INSTALLATION - OPERATIONFinal Check List1. Has the machine been properly uncrated, andhave all packing materials and tape been removedfrom insid

OPERATIONHow does the machine make ice?There are two distinct cycles: freeze and harvest. 1 freeze cycle + 1 harvest cycle = 1 batch of 8cubes.The Fre

COMPONENT LOCATIONReservoirCurtainBinThermostatBracketControl BoxCoverKickplateControl KnobDoor GasketDCE33August 1995Page 14

MAINTENANCE AND CLEANINGWhat shouldn’t be done?Never keep anything in the ice storage bin that isnot ice; objects like wine or beer bottles are notonl

CLEANINGHow to clean the ice making system.1. Open the door andturn the ice machinecontrol knob to off.2. Scoop out all of the ice, either discard it

ADJUSTMENTSThere are three items that may be adjusted: CubeSize, Harvest Time, and Bin Level. Note: CubeSize and Harvest Time adjustments should only

Bin’s ice level.When the ice machine shuts off the ice level in thebin should be even with the metal tube inside thebin. If the ice in the bin is too

SERVICE DIAGNOSISPROBLEM POSSIBLE CAUSE PROBABLE CORRECTIONThe machine does not operate The machine is unplugged Plug the machine in.Breaker tripped o

TECHNICAL INFORMATIONScotsman Ice Systems are designed andmanufactured with the highest regard for safetyand performance. They meet or exceed thestand

SERVICE DIAGNOSISPROBLEM POSSIBLE CAUSE PROBABLE CORRECTIONNo ice falling in bin, but machineoperatesIce may be stuck in theevaporator and the unit is

REPAIRCurtainThe curtain keeps the water that sprayed by thepump from falling in the bin.The "sheet" type curtain is replaced by:1. Removing

REPAIRTimer The timer may need to be replaced if it does notturn, or if it turns and then stops (except at the endof the harvest cycle - the timer wil

REPAIRCube Size ControlThe cube size control controls the timer during thefreeze cycle. If the timer will not start, the cubesize control may be the p

REPAIRSpray PumpThe water pump that forces the water from thereservoir through the spray jets.1. Disconnect electrical power.2. Open the bin door and

INSTALLATIONTo properly make and store ice, the DCE33requires access to air, potable water, 115 voltelectricity and a drain. The machine must beinstal

TO INSTALL: PlumbingThe water supply and drain should be roughed inand ready at the point of installation. A wall outletdirectly behind the ice machin

TO INSTALL: PlumbingFree Standing Cabinet, Gravity DrainModel:All horizontal runs of drain lines must have a 1/4"per foot fall. An air gap will l

TO INSTALL: PlumbingFree Standing Cabinet, Pump Model:1. Remove the kickplate and control box cover.2. Route the water supply, which should be a 1/4&q

TO INSTALL: PlumbingBuilt In, Gravity Drain Model:The drain and inlet water tubes must be plumbedbefore connecting to the ice machine. All horizontalr

TO INSTALL: PlumbingBuilt In Pump Model:1. Place ice machine in front of installed location.Adjust leg levelers to approximately correctposition.2. Re

TO INSTALL: Add On KitsDrain Pump KitThe DCE33 is delivered either with or without adrain pump. Models without a drain pump draintheir water by gravit